Yamaha yz125 service manual repair 2006 yz 125. YAMAHA YZ125 2006 Workshop Service Repair Manual 2019-03-26

Yamaha yz125 service manual repair 2006 yz 125 Rating: 7,7/10 285 reviews

YAMAHA YZ125 2006 Workshop Service Repair Manual

yamaha yz125 service manual repair 2006 yz 125

Install: 9 Aluminum washer 9 Oil drain bolt 1 20 Nm 2. Install the bearing in the bearing races. Alle Teile in sauberem Lösungs- Ensemble fourche avant Montaggio della forcella anteriore mittel reinigen. Toujours arrêter le moteur en bevor aufgetankt wird. Scalding hot fluid and steam may be blown out under pressure, which could cause serious in- jury.

Next

2000 Yamaha YZ125(N)/LC YZ125 Workshop Service Repair Manual DOWNLOAD 00

yamaha yz125 service manual repair 2006 yz 125

Install: 9 Bolt shift guide 1 10 Nm 1. Pass the brake hose through the cable guide 1. Tighten: 9 Adjuster 1 4. Install: 9 Spring 1 9 Link lever 2 9 Collar 3 9 Valve shaft 4 9 Valve holder 5 9 Bolt link lever 6 4 Nm 0. Measure: 9 Runout limit a 9 Small end free play limit b 9 Connecting rod big end side clearance c 9 Crank width d Out of specification ¡.

Next

2000 Yamaha YZ125(N)/LC YZ125 Workshop Service Repair Manual DOWNLOAD 00

yamaha yz125 service manual repair 2006 yz 125

Ispezionare: 9 Axe de piston 9 Spinotto 9 Pleuelfußlager 9 Coussinet de pied de bielle. Remove the stand or block from the engine and with a rider astride the seat, measure the sunken length b between the rear wheel axle center and the rear fender holding bolt. Togliere: 9 Ecrou 1 9 Mutter 1 9 Dado 1 9 Rondelle-frein 2 9 Sicherungsscheibe 2. Tighten all such fasteners as required. To avoid warpage, tighten multi-faste- ner assemblies in a crisscross fashion, in pro- gressive stages, until full torque is reached.

Next

NOW Yamaha YZ125 YZ 125 2006 06 Service Repair Workshop Manual

yamaha yz125 service manual repair 2006 yz 125

Inspect: 9 Cylinder inner surface Score marks ¡ Repair or replace. Pad pin plug: 3 Nm 0. Monter: Ruota anteriore 9 Distanzhülse 2 9 Roulement gauche 1 1. Use the dial gauge 1. Ispezionare: 9 Gicleur principal 1 9 Hauptdüse 1 9 Getto principale 1 9 Support de gicleur principal 2 9 Hauptdüsenhalter 2 9 Supporto del getto principale 2 9 Gicleur de ralenti 3 9 Getto pilota 3 9 Leerlaufdüse 3. When the engine has cooled, open the ra- diator cap by the following procedure: Place a thick rag, like a towel, over the radi- ator cap, slowly rotate the cap counter-. Using the correct special tool will help prevent damage caused by the use of improper tools or improvised tech- niques.

Next

NOW Yamaha YZ125 YZ 125 2006 06 Service Repair Workshop Manual

yamaha yz125 service manual repair 2006 yz 125

Install: 9 Ball 1 9 Retainer 2 To governor shaft 3. Repeat the bleeding procedure when the tiny bubbles in the system have disappeared. When installing a circlip 1, make sure that the sharp-edged corner 2 is positioned opposite to the thrust 3 it receives. Far passare il tubo flessibile del le guide de câble 1. Install the brake hose so that its pipe por- tion a a directs as shown and lightly touch- es the projection b b on the master cylinder.

Next

YAMAHA YZ125(V) OWNER'S SERVICE MANUAL Pdf Download.

yamaha yz125 service manual repair 2006 yz 125

Accordingly, if a mixture of air and fuel is too lean, abnormal combustion will occur, and engine seizure may result. Die Düsennadel-Einstellteile mit dem glei- chen Konuswinkel sind in Ausführungen mit unterschiedlichen Durchmessern des gera- den Teils und mit unterschiedlichen Konus-. Standard tire pressure: 100 kPa 1. Installare: 9 Axe principal 1 Hauptwelle 1 9 Asse principale 1 9 Axe moteur 2 Vorgelegewelle 2 9 Asse motore 2 N. Note the position of each part. Ausbauen: pistone 9 Joint antipoussière 1 9 Staubdichtung 1 1.

Next

YAMAHA YZ125 2006 Workshop Service Repair Manual

yamaha yz125 service manual repair 2006 yz 125

Needle holder Jet needle Float chamber Needle jet cover. Turn the ad- juster 1 1 in. In this revised format, the condition of a faulty component will precede an arrow symbol and the course of action required will follow the symbol, e. Install: 9 Throttle stop screw 1 9 Locknut 2 9 Pilot air screw 3 Note the following installation points:. Installare: 9 Couvercle de carter droit 1 9 Kurbelgenhäusedeckel 9 Copertura del carter destra 1 rechts 1 N. Agganciare: 9 Ressort de torsion 1 9 Torsionsfeder 1 9 Molla di torsione 1 N.

Next

YAMAHA YZ125(V) OWNER'S SERVICE MANUAL Pdf Download.

yamaha yz125 service manual repair 2006 yz 125

Lavare i cuscinetti e le piste con de roulement dans du solvant einem Reinigungsmittel un solvente. Add brake fluid to the level line on the reservoir. This manual is an easy layout format that covers all repair procedures in great detail. Togliere: 9 Axe principal 1 9 Hauptwelle 1 9 Asse principale 1. . Clean: 9 Master cylinder 9 Master cylinder kit Clean them with brake fluid.

Next

Yamaha YZ125 service manual repair 2008 YZ 125

yamaha yz125 service manual repair 2006 yz 125

Installare: 9 Ressort 1 9 Feder 1 9 Molla 1 9 Levier articulé 2 9 Verbindungshebel 2 9 Leva del biscottino 2 9 Collerette 3 9 Piattello 3 9 Hülse 3. B Pass the brake hose into the brake hose hold- ers. Install: 9 2nd wheel gear 29T 1 9 5th wheel gear 24T 2 9 3rd wheel gear 27T 3 9 4th wheel gear 23T 4 9 6th wheel gear 23T 5 9 1st wheel gear 31T 6 To drive axle 7. Installare: 9 Amortisseur arrière 9 Ammortizzatore posteriore Hinterrad-Stoßdämpfer 4. Install: 9 Carburetor joint 1 9 Bolt carburetor joint 2 10 Nm 1. The jet needle setting parts, having the same taper angle, are available in different straight portion diameters and in different taper starting positions. Si dovrebbero ispezionare attenta- doivent être soigneusement véri- dereinbau gründlich prüfen.

Next