Items not listed in the chart should be lubricated at the General Lubrication interval. All information contained within this publication is based on the latest product information at the time of publication. Apply the brakes slightly to aid in slowing, using the single brake lever. Its exceptional frictional properties result in more efficient operation, more power output and lower fuel consumption. Slow down when entering slippery areas. Check the brake system for fluid leaks.
Refer to the gearcase specifications chart on page 76. Dennis Kirk carries more 2005 Polaris Magnum 330 2x4 products than any other aftermarket vendor and we have them all at the lowest guaranteed prices. Reduce speed and allow greater distance for braking when carrying cargo. Maintain a high level of alertness, reading the trail and avoiding quick, sharp turns which can cause skids. Helmet Your helmet is the most important piece of protective gear for safe riding. The rear wheels may skid and slide sideways, causing loss of control and serious injury or death.
Maintenance Interval whichever comes first Miles Km 50 H. Proceed at a steady rate of speed and throttle opening. Always test brake lever travel and master cylinder fluid level before riding. Water accumulation increases as outside temperature decreases. The rear brake system is self-adjusting and requires no maintenance other than periodic checks of the pads for wear. Use a mild detergent to remove any salt, dirt, mud or grime.
Do not service axle nuts that have a cotter pin installed. All service must be performed by your authorized Polaris dealer. Start the engine and allow it to warm up, then shift the transmission into gear. If loose nuts and bolts are found, see your Polaris dealer for service before operating the vehicle. Slide the boots 1 off the inline cable adjuster sleeve 2. Polaris 4-cycle engines are equipped with automatic decompressors.
Description Engine Lubricant 2870791 Fogging Oil 12 oz. The safety alert symbol, on your vehicle or in this manual, alerts you to the potential for personal injury. Always use Polaris-recommended spark plugs. Federal law requires that this spark arrestor be installed and functional when the vehicle is operated on public lands. Avoid operating over large obstacles such as rocks and fallen trees when possible. Your safety is involved when these words and symbols are used.
S Do not smoke or allow open flames or sparks in or near the area where refueling is performed or where gasoline is stored. Keep both feet on the footrests. Due to constant improvements in the design and quality of production components, some minor discrepancies may result between the actual vehicle and the information presented in this publication. Since you already have a maintenance manual that youve been using for routine maintenance, you need only assure that you have on hand a parts catalogue for any repairs that are necessary. Do not aggressively apply the auxiliary brake when going forward.
When inspection reveals the need for replacement parts, use genuine Polaris parts available from your Polaris dealer. To enter the diagnostics mode: 1. Always block the rear wheels on the downhill side. Loosen the adjuster locknut 3. Contents include the following topics with exploded diagrams and part number lists.
A helmet can prevent a severe head injury. Your key can be duplicated only by mating a Polaris key blank with one of your existing keys, so if both keys are lost, the ignition switch must be replaced. Remove the taillight lens cover mounting screws. Avoid crossing the side of a hill when possible. Always remove the ignition key when the vehicle is not in use.
Choose a crossing where both banks have gradual inclines. Do not attempt to adjust tie rod alignment. Wash the pre-filter in soapy water, then rinse and let dry. Squeeze and release the brake lever 1 two or three times, then squeeze and hold. Aerosol 2871281 Premium 4 Synthetic 0W-40 4-Cycle Engine Oil qt. Loosen the clamp and remove the filter. The front and rear brakes are hydraulically activated disc type brakes that are activated by only one lever.